WSHP-SVX04A-ENModels“A” and later Design SequenceInstallationOwnerDiagnosticsExtra High EfficiencyWater-Source Heat PumpModels WPVJ and WPHFWPVJ018-07
10 WSHP-SVX04A-ENDimensionsWPVJ 030-042 LH
WSHP-SVX04A-EN 11DimensionsWPVJ 030-042 RH
12 WSHP-SVX04A-ENDimensionsWPVJ 048-072 LH
WSHP-SVX04A-EN 13DimensionsWPVJ 048-072 RH
14 WSHP-SVX04A-ENGeneral Installation ChecksThe checklist below is a summary of the steps required to successfully in-stall a unit. This checklist is
WSHP-SVX04A-EN 15Unit Installation; WPVJDuct collars are provided for the WPVJ equipment. The duct system and dif-fusers should be sized inaccordance
16 WSHP-SVX04A-ENUnit Installation; WPHFDuct collars are provided for the WPHF equipment. The duct system and dif-fusers should be sized inaccordance
WSHP-SVX04A-EN 17Connecting a Distributed Pump Kit to a Closed Loop SystemAll piping external to the unit is the re-sponsibility of the installer. The
18 WSHP-SVX04A-ENField Installed Power WiringPower wiring to the equipment must conform to National and Local Electric Codes (NEC) by a professional e
WSHP-SVX04A-EN 19Low Voltage Wiring for Field Provided Thermostats/Zone SensorsEnsure that the AC control wiring be-tween the controls and the unit’s
© 2003 American Standard Inc. All rights reserved. WSHP-SVX04A-ENNoticeNOTICE:Warnings and Cautions appear at appropriate sections throughout this man
20 WSHP-SVX04A-ENTable E1: WPVJ Electrical Performance (Standard Static Blower Option) Model No. Volts/Hz/Ph TotalFLAComp.RLA (ea)Comp.LRA (ea)No. ofC
WSHP-SVX04A-EN 21Table E1: WPVJ Electrical Performance (Standard Static Blower Option-continued)Table E2: WPVJ Electrical Performance (High Static Blo
22 WSHP-SVX04A-ENTable E2: WPVJ Electrical Performance (High Static Blower Option-continued) Model No. Volts/Hz/PhTota lFLAComp.RLA (ea)Comp.LRA (ea)N
WSHP-SVX04A-EN 23Table E2: WPVJ Electrical Performance (High Static Blower Option-continued)Table E3: WPHF Electrical Performance (Standard Static Blo
24 WSHP-SVX04A-ENTable E3: WPHF Electrical Performance (Standard Static Blower Option-continued)Table E4: WPHF Electrical Performance (High Static Blo
WSHP-SVX04A-EN 25Pre-StartChecklistPre-Start-up ChecklistBefore energizing the unit, the following system devices must be checked:____ Is the high vo
26 WSHP-SVX04A-ENInitial Unit Start-upStart-up for 24V (basic) controls is included below: Note: Start-up for the TracerTM ZN510 controller may be fou
WSHP-SVX04A-EN 27Operating PressuresGENERAL: There are many variables (airflow, air temperatures) in an air conditioning system that will affect opera
28 WSHP-SVX04A-ENTable OP-1: Operating pressures and temperature for PSC motorUnits with PSC motors Operating DataCooling HeatingModel Entering Water
WSHP-SVX04A-EN 29Operating PressuresWater Pressure DropTable 4 should be used to define feet of head/pressure drop. Note: To calculate feet of head, w
WSHP-SVX04A-EN 3ContentsInstallation/Startup/Commissioning4Pre-installation Checklist4General Information5Dimensions/Weights6Installation Instructions
30 WSHP-SVX04A-ENStart-up Checklistand LogInstalling Contractor: Use this form to thoroughly check-out the system and units before and duringstart-up.
WSHP-SVX04A-EN 31Preventive MaintenanceMaintenance on the unit is simplified with the following preventive sugges-tions:Filter maintenance must be per
32 WSHP-SVX04A-ENWarranty InformationStandard WarrantyThe standard water-source heat pump warranty is Trane’s parts-only warranty, running 12-months f
WSHP-SVX04A-EN 33WARNINGHazardous Service Procedures!The maintenance and trouble shooting procedures recommend-ed in this section of the manual could
34 WSHP-SVX04A-ENTroubleshootingChecklistProblem Heating Cooling Cause CorrectionNo response to anythermostat settingX X Main power off Check fusesX X
WSHP-SVX04A-EN 35Unit WiringWPVJ Basic 24V Diagram
36 WSHP-SVX04A-ENUnit WiringWPVJ Tracer ZN510 Diagram
WSHP-SVX04A-EN 37Unit WiringWPHF Basic 24V Diagram
38 WSHP-SVX04A-ENUnit WiringWPHF Tracer ZN510 Diagram
Trane has a policy of continuous product and data improvement and reserves the right to change design and specifications without notice.Literature Or
4 WSHP-SVX04A-ENWARNINGFiberglass Wool!Product contains fiberglass wool. Disturbing the insulation in this product during installation, maintenance or
WSHP-SVX04A-EN 5GeneralInformationUnit NameplateThe unit nameplate is located at the front of the unit. It includes the unit model number, serial numb
6 WSHP-SVX04A-ENTable 1: Unit weights SizeShipping Weightwith pallet (lb)Shipping Weightw/o pallet (lb)WPVJ018 249 239024 250 240030 298 288036 315 30
WSHP-SVX04A-EN 7DimensionsWPHF 021-057
8 WSHP-SVX04A-ENDimensionsWPVJ 018-024 LH
WSHP-SVX04A-EN 9DimensionsWPVJ 018-024 RH
Kommentare zu diesen Handbüchern